Product ID:HATCOL 1280 (MIL-L-7808J)
MSDS Date:09/12/1990
FSC:9150
NIIN:00-108-5359
MSDS Number: BJFMK

HATCO CORP.

KING GEORGE POST ROAD
FORDS, NJ 08863
US

Emergency Phone: 201-738-3568

Info Phone: 201-738-1000

Preparer: C. LYNCH

Cage: KO092

UNIMARK OIL COMPANY (FORMERLY GARD OIL)

KANSAS CITY, KS 66103-1543 US

Telephone: 913-236-5000; FX 913-236-4419

Cage: 3K676

MIXED TRIMETHYLOLPROPANE ESTERS

CAS: 67762-64-5

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

NEOPENTYL GLYCOL, CAPRYLIC/CAPRIC ESTERS

CAS: 70693-32-2

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

MIXED TRIMETHYLOLPROPANE ESTERS

CAS: 68130-53-0

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

TAR ACIDS, CRESYLIC,PHENYL,PHOSPHATE

CAS: 68952-35-2

DIOCTYL DIPHENYL AMINE

CAS: 26603-23-6

LD50 LC50 Mixture:ORAL LD50 (RAT) IS >5 G/KG ESTIMATED
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY BE AN EYE OR SKIN IRRITANT. LOW TO
MEDIUM TOXICITY.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:GENERALLY CONSIDERED MINIMALLY IRRITATING TO
THE EYES AND MILDLY IRRITATING TO THE SKIN. PROLONGED AND REPEATED
CONTACT MAY RESULT IN VARIOUS SKIN DISORDERS SUCH AS DERMATITIS,
FOLLICULITIS OR OIL ACN E. INHALATION OF VAPOR OR OIL MIST MAY
CAUSE MILD UPPER RESPIRATORY TRACT IRRITATION. SLIGHTLY TOXIC IF
SWALLOWED.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:SKIN: REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER.
GET MEDICAL ATTENTION IF IRRITATION DEVELOPS. INHALATION: REMOVE TO
FRESH AIR & RESTORE BREATHING IF NECESSARY. GET MEDICAL ATTENTION.
EYE : IMMEDIATELY FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. INGESTION: MAY ACT AS A
LAXATIVE. DO NOT INDUCE VOMITING. RELATIVELY NON-TOXIC UNLESS
ASPIRATED.

Flash Point Method:COC
Flash Point:410F,210C
Extinguishing Media:USE CARBON DIOXIDE, FOAM OR DRY CHEMICAL
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS. WATER MAY CAUSE
FROTHING.

Spill Release Procedures:CONTAIN SPILL IMMEDIATELY. DO NOT ALLOW SPILL
TO ENTER SEWERS OR WATERCOURSES. REMOVE ALL SOURCES OF IGNITION.
ABSORB WITH APPROPRIATE INERT MATERIAL SUCH AS SAND, CLAY, ETC. PUT
IN DISPOSAL CONTAINER AND SEAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:FOR INDUSTRIAL USE ONLY. STORE IN
COOL, DRY PLACE. KEEP CONTAINER CLOSED WHEN NOT IN USE.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
LAUNDER CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICL ES THAT CANNOT BE DECONTAMINATED.

Respiratory Protection:USE NIOSH/MSHA APPROVED AIR-PURIFYING RESPIRATOR
FOR ORGANIC VAPORS.
Ventilation:MECHANICAL AND LOCAL EXHAUST RECOMMENDED IF USED IN
ENCLOSED AREA.
Protective Gloves:NEOPRENE GLOVES
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:WEAR PROTECTIVE CLOTHING, NEOPRENE APRON AND
BOOTS AS REQUIRED TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices:WASH WITH SOAP AND WATER AFTER CONTACT. AVOID
INGESTION. PRACTICE GOOD PERSONAL HYGIENE.
Supplemental Safety and Health
THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER SECTION 311 OF THE CLEAN
WATER ACT. SPILLS ENTERING SURFACE WATERS OR ANY WATER COURSES OR
SEWERS ENTERING/LEADING TO SURFACE WATERS THAT CAUSE A SHEEN MUST
BE REPORTED TO THE NATIONAL RESPONSE CENTER AT 800-424-8602.

HCC:V6
Boiling Pt:B.P. Text:>440F,>227C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:NOT GIVEN
Vapor Density:NOT GIVEN
Spec Gravity:0.95
Viscosity:3-17,000 CS
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR OILY LIQUID, MILD ODOR
Percent Volatiles by Volume:0 %

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG ALKALIS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE

Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR
OR DISPOSED OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND
FEDERAL REGULATIONS. RECYCLE IF POSSIBLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.